• 回到顶部
  • 4008269815
  • QQ客服
  • 微信二维码
首页    智能低压粉料输送系统    智能低压粉料输送系统

智能低压粉料输送系统

本方案为单台低压螺杆空压机粉料输送方案设计......

本方案为单台低压螺杆空压机粉料输送方案设计,空压机安装 在机房内直接使用管道将压缩空气接驳在罐车压缩空气接驳车,中 间无需另外接储气罐、冷干机及油水分离设备,运转稳定、方便快 捷、节能高效。

This scheme is designed for the powder conveying scheme of a single low-pressure screw air compressor. The air compressor is installed in the machine room and compressed by pipes directly.

 

2323

 

产品优点:

● 行业专用设计:

针对搅拌站研发的建材低压污水设计方案超强油分系统,独特的除水工艺设计,同事剔除了工业螺杆机不适合的工艺。

● 噪音低:

有效的消除砼站生产场地内最大的噪音源- - -柴油机和摆式空压机,在搅拌站中心点实测噪音排放在58-63分贝之间,符合国家标准70分贝及以下,为砼站及周边人民的生产生活营造安静的办公作业环境。

● 排出空气完全除水:

为适应行业无水要求,采用独特技术工艺,排气温度82-91度,空气中的水分被除去,真正达到空气相对湿度为0,含水量为0 (全无 水),全系统无需额外增加储气罐和冷干机。从而避免增加除水设备也不能完全除水的难题。

● 质量稳定可靠:

采用德国进口特制低压技术螺杆主机,智能化电气控制系统,可连续24小时运行,设计使用寿命30年,主机质保2年,无易损件,更 耐用,更适合于搅拌站的特殊工况和环境。

● 高效环保节能:

采用电能取代传统机型油耗,提升输送效率30%以上,实测吹灰能力1.2T/min,大大降低了输送成本,真正实现高效、环保、节能。

1.Industry-specific design:

For the mixing plant research and development of building materials low-pressure sewage design scheme, super oil system, unique water removal process design, colleagues eliminated the industrial screw machine is not suitable for the process.

2.Low noise:

Effectively eliminate the biggest noise source in the concrete station production site - diesel engine and tilting air compressor, the noise emission measured in the center of the mixing station is between 58-63 db, in line with the national standard of 70 db and below, for the concrete station and the surrounding people's production and life to create a quiet office environment.

3.Exhaust air completely dehydrates:

In order to adapt to the industry anhydrous requirements, a unique technology is adopted. The exhaust temperatureis 82-91 degrees, and the moisture in the air is removed to truly achieve the air relative humidity of 0, water content of 0 (total anhydrous), and the whole system does not need to add additional gas storage tank and cold dryer. So as to avoid the increase of the water removal equipment can not completely remove the water problem.

4.Stable and reliable quality:

Adopt special low-voltage technology imported from Germany screw main machine, intelligent electrical control system, can run continuously for 24 hours, designed service life of 30 years, the main machine warranty for 2 years, no wearing parts, more durable, more suitable for the mixing station's special working conditions and environment.

5.High efficiency, environmental protection and energy saving:

The fuel consumption of traditional models is replaced by electric energy, and the conveying efficiency is increased by more than 30%. The measured blowing capacity is 1.2t /min, which greatly reduces the conveying cost and truly achieves high efficiency, environmental protection and energy saving.

 

系统示意图   

 

A20

 

1212

 

A21

 

 

系统示意图   

22

 

适用行业  

 

水泥中转库,混凝土搅拌站环保专用外接气源,氧化钙厂、矿粉厂、工地、罐船卸料、粮食等一切粉料输送行业。

优点:全无水、上气快、效率高、可耐高压、噪音超低、可连续24小时不间断工作等。

Cement transfer depot, concrete mixing station environmental protection special external gas source, calcium oxide plant, ore powder plant, construction site, can ship unloading, grain and other powder conveying industry.

Advantages: no water, fast gas, high eficiency, can withstand high pressure, ultra-low noise, can work continuously for 24 hours.

奇领yy6080在线视频观看/不用充钱的看黄神器/99r8这是只有精品视频2019/在软卧铺车上摸两乳